Cars > redraif’s Garage > Blog > 1984 Pontiac Fiero (Stormtrooper) > The repair list to date
redraif’s Blog Posts 1 – 5 of 5
- TV Show (7/23) with me and the Stang...Help me find it...
- Wed Jul 22, 2009 | 4 comments
- Sometimes you just wonder about your "friends"
- Tue Aug 12, 2008 | 3 comments
- 2005: Spark plug HELL!
- Mon Aug 11, 2008 | 4 comments
- The repair list to date
- Sun Aug 10, 2008 | comment
- Getting the car running right (the never ending saga)
- Sun Aug 10, 2008 | comment

The repair list to date
Aug 10, 2008 | Views: 601
Filed under: 1984 Pontiac Fiero (Stormtrooper)
Share this story
Basics
Oil Change
New belts
New pcv
New Air filter
New Valve cover gasket
New used valve cover
New TB gasket
New vacuum lines (red silicone)
New TPS
Electrical
New battery (4)
New dist cap and rotor button
New wires
New plugs
New starter (2)
New coil
New ECM
New grounds, cleaned all mounting points
New ignition switch
Fixed previous owners rewiring disaster of all power wires and cut A/C wires
Cooling system...
New coolant hoses (all)
New radiator cap
New thermostat cap
New thermostat
New temperature sensor (ECM)
New temperature gauge and pod to hold it (original broken even with electrical repairs made)
New water pump after it sprayed like a volcano out the weep hole
New coolant (obviously) LOL!
Rigged fan to run on ignition hot to bypass bad switch
Fuel
New fuel filter
New fuel pump
Transmission (manual)
New clutch
New slave (2)
New master cylinder
New fluid
New used clutch arm and petal
New driver’s side axle
Exhaust
New EGR gasket
New O2 sensor
Cut off defective water logged stock catalytic converter & water logged stock muffler
Replaced with 2.8L (1.5inch) Firebird piping, 1.5inch cutout, and Flowmaster muffler
Brakes
New front calipers
New pads (all)
New rear rotors
New stainless braided brake lines
New park brake cables and equalizer
New prop valve
New master cylinder
New fluid
Adjusted rear caliper's parking brake arms to make PB function properly (still INOP)
Suspension
New shocks
New struts
New passenger side front lower ball joint
New passenger side cv axle inner boot
Body stuff
New used spoiler (original split and was full of water)
New used trunk carpet (original water soaked from leaky spoiler)
New used tail lights (original melted)
New used rear view and side mirror
New inner and outer dew wipes
Lubed and cleaned power window motors and switches
Replaced busted door lock inner rod connector
Drilled holes to help w/ sunroof leak per GM service bulletin
Replacing ribbed body side molding with smooth.
Patched holes in the floor and firewall
Interior
Replaced headliner fabric
Pepaired headliner board
Replaced and or cleaned all interior panels
Repaired radio console, center console, and internal framework
Permanent Link to this Blog Post:
Log in to post comments.
Read comments on this blog post
No comments have been posted on this blog post.
Cars > redraif’s Garage > Blog > 1984 Pontiac Fiero (Stormtrooper) > The repair list to date